![]() |
|
Post Reply ![]() |
Author | ||
bbsrs ![]() Newbie ![]() ![]() Joined: 10-May-2009 Location: limerick /ireland Status: Offline Points: 9 |
![]() ![]() ![]() ![]() ![]() Posted: 10-May-2009 at 11:49 |
|
Hi, E30 M3 2.3 1988 ,My car idles fine , under slow acceleration no real problems ,but under hard acceleration the car feels/sounds like it overfuelling badly missing with lots of flat spots.I've put in a new set of sparkplugs (nil fix) and the HT leads seem to be in good condition. Also sometimes when i turn the engine off it splutters on for a few seconds like older cars do when the timing is out ,so I'm wondering is the timing out and if so how can the timing be adjusted on an S14, ECU change? One other annoying problem is above 4000rpm the gearstick rattles/buzzs really loudly,any ideas on how to get rid of this noise. Cheers. |
||
![]() |
||
Sponsored Links | ||
![]() |
||
Hoover ![]() Bavarian-Board Contributor ![]() ![]() black beast with four legs Joined: 04-October-2006 Location: southampton Status: Offline Points: 505 |
![]() ![]() ![]() ![]() ![]() |
|
gear stick buzz is a must for an m3 mate sounds like overfuelling, is it standard car, afm?. any history, it is possible to tamper with the spring in the afm and affect things badly - job to know without sticking on a gas analyser, or better still i know a bloke who will diagnose and sort....eh shep? |
||
88 E30 M3 fast(er than it was, ta Shep and Grant)
and a k8 2008 busa...faster still (focus RS gone to good home - but never forgotton, eh Shep) |
||
![]() |
||
SHEPSM3 ![]() Bavarian-Board Contributor ![]() ![]() UK Sport Evolution. Joined: 26-December-2004 Location: Bristol, UK. Status: Offline Points: 1934 |
![]() ![]() ![]() ![]() ![]() |
|
The buzzing gearknob can be sorted, but usually means replacing bushes, clips, etc, even the knob itself. If it feels sloppy, best replace the gear linkage bushes and/or the linkrods/pins. Not a bad job to do actually. The running on... this is a weird one... I have never heard of an E30 M3 running on. But, I suppose it could if it had an air leak on the Throttle body blocks causing high combustion chamber temperatures..... leading to hot carbon deposits in the head.... leading to your running on problem, also possibly causing your "over fueling" problems. Other than that, there are several other things which can cause your flat spots. Its best to put the car on a rolling road with an oscilloscope connected to the ignition system, a CO/HC emission tester up the exhaust and a couple of runs on the dyno while all thats connected. Other things to check are HT leads are fully home inside the dissy cap. Check the cap for cracks, damage and all electrodes inside the cap are in good condition. Also while there, check the rotor arm for cracks, etc. Put an ohms meter across the rotor arm (middle to end of metal contact and see what the reading is. There should be a resistance, but not too high. I will need to check what it should be, but if you have a reading of infinity, althought the car will still run, it can cause the problems you describe. AFM (Air flow meter) do wear and cause problems, Also, the blue temp sensor in the water rail above the exhaust can cause similar problems too. What temperature does the engine run at when running normally? If just below the half way mark on the gauge, as long as the black temp sensor is in good condition, this is fine. If it stays around the 1/4 mark or lower, this is running too cold... again assuming the black temp sensor is good. The blue sensor is what gives the ECU engine temperature info. The black one does the gauge. But a dyno run will show everything up. These engines and you E28 M5 benefit greatly to a full ignition timing and fueling remap with the AFM removed. As to the ignition timing being out, unless there is interferrance to the 2 crank sensors or the ECU, the timing will not be out. It is ECU controlled. Paul. |
||
[IMG]http://i4.photobucket.com/albums/y135/ShepsM3/New-1a1.jpg">[IMG]http://i4.photobucket.com/albums/y135/ShepsM3/New-1b1.jpg">
|
||
![]() |
||
bbsrs ![]() Newbie ![]() ![]() Joined: 10-May-2009 Location: limerick /ireland Status: Offline Points: 9 |
![]() ![]() ![]() ![]() ![]() |
|
Paul, Thanks for the information ,I'll check out as much as i can going on your suggestions. Have you the facilities to carry out rolling road testing and tuning ect. and if I dont get it sorted would you check it out for me. |
||
![]() |
||
Hoover ![]() Bavarian-Board Contributor ![]() ![]() black beast with four legs Joined: 04-October-2006 Location: southampton Status: Offline Points: 505 |
![]() ![]() ![]() ![]() ![]() |
|
....yes he has mate and does a top job!
|
||
88 E30 M3 fast(er than it was, ta Shep and Grant)
and a k8 2008 busa...faster still (focus RS gone to good home - but never forgotton, eh Shep) |
||
![]() |
||
SHEPSM3 ![]() Bavarian-Board Contributor ![]() ![]() UK Sport Evolution. Joined: 26-December-2004 Location: Bristol, UK. Status: Offline Points: 1934 |
![]() ![]() ![]() ![]() ![]() |
|
Thanks Nick! BBSRS... Yes, I have a rolling road and can carry out all the testing needed to sort it. I'll pm you my number |
||
[IMG]http://i4.photobucket.com/albums/y135/ShepsM3/New-1a1.jpg">[IMG]http://i4.photobucket.com/albums/y135/ShepsM3/New-1b1.jpg">
|
||
![]() |
||
thepits ![]() Moderator Group ![]() ![]() Joined: 09-July-2003 Location: far far away Status: Offline Points: 10000473 |
![]() ![]() ![]() ![]() ![]() |
|
![]() once I'd replaced the engine so, it's worth a check - isn't it? |
||
Cats know your every thought.
But don't care. |
||
![]() |
||
SHEPSM3 ![]() Bavarian-Board Contributor ![]() ![]() UK Sport Evolution. Joined: 26-December-2004 Location: Bristol, UK. Status: Offline Points: 1934 |
![]() ![]() ![]() ![]() ![]() |
|
Blimey Simon, I remembered you replaced your engine for some reason, but couldn't remember why... its all come back to me now. |
||
[IMG]http://i4.photobucket.com/albums/y135/ShepsM3/New-1a1.jpg">[IMG]http://i4.photobucket.com/albums/y135/ShepsM3/New-1b1.jpg">
|
||
![]() |
||
bbsrs ![]() Newbie ![]() ![]() Joined: 10-May-2009 Location: limerick /ireland Status: Offline Points: 9 |
![]() ![]() ![]() ![]() ![]() |
|
thepits, definitly worth a look mate, Cheers. |
||
![]() |
||
UweM3 ![]() Moderator Group ![]() ![]() Joined: 11-February-2003 Location: United Kingdom Status: Offline Points: 5445 |
![]() ![]() ![]() ![]() ![]() |
|
I am sure he over revved it ![]() |
||
E61 520d, slow and buzzy but my wallet likes the mpg.....
|
||
![]() |
||
Hoover ![]() Bavarian-Board Contributor ![]() ![]() black beast with four legs Joined: 04-October-2006 Location: southampton Status: Offline Points: 505 |
![]() ![]() ![]() ![]() ![]() |
|
...funny place to have a valve spring Simon, in a gear stick!
![]() |
||
88 E30 M3 fast(er than it was, ta Shep and Grant)
and a k8 2008 busa...faster still (focus RS gone to good home - but never forgotton, eh Shep) |
||
![]() |
Post Reply ![]() |
|
|
Forum Jump | Forum Permissions ![]() You cannot post new topics in this forum You cannot reply to topics in this forum You cannot delete your posts in this forum You cannot edit your posts in this forum You cannot create polls in this forum You cannot vote in polls in this forum |